High Pressure Washers

20 Comments / High Pressure Cleaning / By

High Pressure Washers

vipfs employee using high Pressure Washing the driveway

You’ve tried water. You’ve tried soap. You’ve tried scrubbing and scouring. You’ve tried nasty chemicals that don’t do what they say. So what do you do when it won’t come clean? Roll out the pressure washer! Many people now routinely use these super-powerful hoses (also known as “power washers”) to blast things clean with water jets pressurized at about 100–200 times the pressure of the air around us (that’s 1500–3000 pounds per square inch or psi). They’re brilliant on patios, drives, lawn furniture, barbecue grills, and all kinds of other outside grime. Let’s take a closer look at how they work!

Why pressure jets get things cleaner

There’s a good scientific reason why water gets things so clean: its molecules have a slight electrical polarity (one end is positively charged and the other is negatively charged), so they tend to stick to things all by themselves. Detergents (soap chemicals) help water to do its job even better by breaking down gunge and grease and making it easier for water to flush away. But some kinds of ground-on dirt just won’t budge, no matter how hard you try. That’s when a pressure washer comes in really handy. It uses a narrow, high-pressure jet of hot or cold water to blast dirt free. Because the water is traveling fast, it hits the dirty surface with high kinetic energy, knocking dirt and dust away like a constant rain of tiny hammer blows. It’s only water, though, so it doesn’t damage most hard surfaces. Having said that, it’s a good idea to test a pressure washer on an inconspicuous area before you start work to make sure it doesn’t harm the surface you’re cleaning. Always read the instructions before you use a pressure washer!

Parts of a pressure water

A pressure washer is less sophisticated than it sounds. It’s really just a water pump powered by an electric motor. The washer takes in ordinary water from a faucet (that’s a tap to you folks in the UK), the pump accelerates the water to high pressure, and then squirts it from a hose at speed through a trigger gun. You can fit various other attachments to the end of the hose for cleaning different things.

These, then, are the main parts you’ll find inside a pressure washer:

  • Water inlet: A hose that connects the pressure washer to the main water supply. There’s usually a filter in the inlet to stop dirt and debris entering the washer and clogging up the works. Little bits of grit are the last thing you want inside your washer—especially since they could come blasting out of the other end at high speed!
  • Electric motor or gas engine: Most smaller, pressure washers (such as the very popular ones made by Kärcher) run off the domestic electricity supply, but bigger models are powered by compact gasoline engines. The engines are similar to the ones you’d find in lawnmowers (typically power rated at around 3–4kW or 3.5–5.5HP). Gas engine models are great if you’re working outside in places where an electricity supply is hard to find (or where a long trailing cable would be dangerous or inconvenient). The motor or engine is designed to power the water pump.
  • Water pump: This is the heart of a pressure washer. It’s a bit like a hand-operated ground-water pump—only it’s driven at high speed by the electric motor (or gas engine) instead of your hand. When the engine pulls the pump one way, it sucks water in from the faucet; when it pushes the pump the other way, the water squirts out in a high-pressure jet. Pumps are designed to handle a water flow of around 1–2 gallons (4–8 liters) per minute.
  • High-pressure hose: This is the tube that runs out from the washer to whatever cleaning attachment you’ve decided to use. An ordinary bit of tubing wouldn’t be able to survive the high-pressure of the water flowing through it. High-pressure hose is reinforced with wire mesh and has two or more layers of high-density plastic. It’s important to use hose that has a higher pressure rating than the pump in your pressure washer but, if your washer came with your own hose, there shouldn’t be anything to worry about. Typically, the safety margin on pressure-washer hoses is about 300 percent, so if your washer is rated at 2000 psi, your hose should be able to withstand pressures of at least 6000 psi.
  • Cleaning attachment: Depending on what you’re cleaning, you can switch from a simple trigger gun (essentially just a valve that lets water through only when you squeeze the handle) to a spinning wand spray or a rotating brush to scrub your drive. Powered attachments are driven by the force of the water flowing through them.

Some pressure washers have additional features. Water and electricity are not a good mix, so many power washers have ground-fault circuit breakers, also known as residual current devices (RCDs), built into the power supply to protect you in case of an electrical fault. Most washers work in the same way and do exactly the same kind of thing, but the more expensive ones tend to operate at higher water pressures (and have better cleaning power).

Hig Pressure cleaning

Drawbacks of pressure washers

Pressure washers can get things really clean, but they have a few problems too:

  • They use a lot of water (typically 1.5–2 gallons per minute). That water needs to move away quickly, so you’ll need good drainage where you’re working if you don’t want to cause a flood.
  • They’re noisy (sound levels are usually about 75–90dBA).
  • They can make everything around them (including you!) very dirty by blasting filth in all directions. Think carefully about the order or direction in which you’ll be working to minimize how much cleaning up you’ll need to do later. Choose your attachments wisely to avoid making too much mess, and be sure to wear waterproof, protective overalls and shoes.
  • Although power washers are insulated and very safe to use, there’s always a risk of using electricity near water, so be sure to work with an RCD unless you’re using a gasoline-powered machine.
  • Pressure washers are blunt instruments, not always suitable for cleaning delicate fixtures and fittings. Used the wrong way, they can damage wooden decking and penetrate the weakening seals of old windows, making them more prone to leaks or (in the case of double-glazing) “fogging up.” If you’re unsure, try your washer on an inconspicuous area first—and use with a low-power setting (or a wide nozzle) before upping the power (or using a narrower nozzle) once you feel it’s safe to do so.

Got any questions about pressure washing? Call VIP Facility Services  at 0432225070 today! Simply call us or leave a message to request a fast, free estimate.

Get a Quote

SHARE THIS


20 thoughts on “High Pressure Washers”

  9. Agustin

    Thanks on your marvelous posting! I truly enjoyed reading
    it, you might be a great author.I will make certain to bookmark your blog and will eventually come back in the future.
    I want to encourage one to continue your great writing,
    have a nice evening!

  10. Esmeralda

    Do you mind if I quote a few of your articles as long as I provide credit
    and sources back to your blog? My website is in the
    very same area of interest as yours and my visitors would truly benefit from some of the information you present here.
    Please let me know if this ok with you. Thanks a lot!

  12. ps4 games when

    I all the time used to study post in news papers but now as I
    am a user of internet therefore from now I am using net for articles
    or reviews, thanks to web.

  13. your ps4 games

    Thanks , I have just been looking for information about this subject for a while
    and yours is the best I’ve came upon so far. But, what
    concerning the bottom line? Are you certain in regards
    to the source?

  15. Bradley

    Its like you read my thoughts! You seem to understand a lot about
    this, like you wrote the e book in it or something. I think that you just can do
    with some p.c. to drive the message house a bit, however other
    than that, that is magnificent blog. A fantastic
    read. I’ll certainly be back.

  16. Mavis

    Thanks for the good writeup. It actually used to be a enjoyment
    account it. Look complex to far added agreeable from you!
    However, how could we keep in touch?

  17. Suzanne

    Thanks on your marvelous posting! I definitely enjoyed reading it, you may be
    a great author. I will make certain to bookmark your blog and will
    eventually come back very soon. I want to encourage
    one to continue your great posts, have a nice morning!

  18. Rosario

    Greate pieces. Keep posting such kind of information on your
    site. Im really impressed by it.
    Hello there, You’ve performed an incredible job.
    I will definitely digg it and personally suggest to my friends.
    I am confident they will be benefited from this website.

Comments are closed.